Honda HRR216TDA Manuale Utente

31VG464200X31-VG4-642040000.2003.07PRINTED IN U.S.A.POM52774-G© 1997–2003 American Honda Motor Co., Inc.—All Rights ReservedRotary MowerHRS216PDA • H

CONTROLS & FEATURES8REAR DISCHARGE GUARD(HRR, HRZ)MULCHING PLUG (HRR, HRZ)SHIFT LEVER (TDA)THROTTLE LEVERHANDLEBAR LOCKINGKNOB (2)FUEL VALVEAIR CL

CONTROLS & FEATURES9DESCRIPTION OF CONTROLSFuel ValveThe fuel valve controls fuel flow from the fuel tank to the carburetor. The fuel valve must b

CONTROLS & FEATURES10Drive Clutch Lever (SDA, TDA) The drive clutch lever engages and disengages the transmission that drives the rear wheels. Th

CONTROLS & FEATURES11Cutting Height Adjustment LeversThe mower deck can be set to any of the six approximate settings. Each wheel should be adjust

12BEFORE OPERATIONARE YOU READY TO GET STARTED?Your safety is your responsibility. A little time spent in preparation will significantly reduce your r

BEFORE OPERATION13Check the General Condition of the Lawn Mower:• Look around and underneath the lawn mower for signs of oil or gasoline leaks.• Look

BEFORE OPERATION14Mulching Plug (HRR, HRZ)The mulching plug helps to curve the inside of the mower deck for more efficient mulching.Install and remove

BEFORE OPERATION15Grass Bag (HRR, HRZ)A lawn mower works like a vacuum cleaner; it blows air through the bag, which traps the grass clippings. Always

16OPERATIONMOWING PRECAUTIONSBefore operating the mower for the first time, please review the LAWN MOWER SAFETY chapter beginning on page 4 and the BE

OPERATION173. SDA, TDA: Release the drive clutch lever (page 10). If the drive clutch lever is engaged, the mower will move forward when you operate t

Keep this owner’s manual handy, so you can refer to it at any time. This owner’s manual is considered a permanent part of the lawn mower and should re

OPERATION18OPERATING THE CONTROLS FOR MOWING Throttle Lever For best cut quality, always mow with the throttle lever in the FAST position. When the

OPERATION19Drive Clutch Lever (SDA, TDA) Push the drive clutch lever forward and hold it against the handlebar to propel the mower forward.Release th

OPERATION20Caster Wheel Lock Lever (HRZ)Use the caster wheel lock lever to hold the front wheels in the straight ahead direction. The lock lever can b

OPERATION21STOPPING THE ENGINE 1. Move the throttle lever to the SLOW position.2. Release the drive clutch lever (SDA, TDA).3. Release the flywheel

OPERATION22SAFE MOWING PRACTICES For your safety, keep all four wheels on the ground, and be careful to avoid losing your footing and control of the

OPERATION23ObstaclesUse the side of the mower to cut close to obstacles, such as fences or walls. Release the drive clutch lever to disengage the driv

OPERATION24MOWING TIPSWhich Blade?Grasses and lawn conditions vary greatly, so Harmony II models can use various combinations of standard and accessor

OPERATION25Cutting WidthFor an even lawn finish, overlap each mowing swath by a few inches. If the grass is very tall or thick, use more overlap and a

OPERATION26Dry GrassIf the ground is too dry, mowing will stir up a lot of dust. Besides being unpleasant to work in, too much dust will clog the air

OPERATION27Mowing PatternsYour Honda mower will work most efficiently if you use the following mowing patterns as much as possible. Mower deck and equ

INTRODUCTION1Congratulations on your selection of a Honda lawn mower! We are certain you will be pleased with your purchase of one of the finest lawn

28SERVICING YOUR MOWERTHE IMPORTANCE OF PROPER MAINTENANCEProper maintenance is essential for safe, economical, and trouble-free operation. It will al

SERVICING YOUR MOWER29MAINTENANCE SAFETYSome of the most important safety precautions follow. However, we cannot warn you of every conceivable hazard

SERVICING YOUR MOWER30MAINTENANCE SCHEDULE(1) Service more frequently when used in dusty areas.(2) These items should only be serviced by an authorize

SERVICING YOUR MOWER31BLADE(S)1. Turn the fuel valve to OFF (page 9). Disconnect the spark plug cap from the spark plug (page 37).2. Tilt the mower to

SERVICING YOUR MOWER32Blade Removal and InstallationIf you remove the blade(s), use a torque wrench for installation. Wear heavy gloves to protect you

SERVICING YOUR MOWER33Blade Installation1. Clean around the blade holder. Install the blade(s) using the bolts and special washers as shown [concave s

SERVICING YOUR MOWER34ENGINE MAINTENANCEEngine Oil Level Check1. Wipe the dipstick clean.2. Insert and remove the dipstick without screwing it into th

SERVICING YOUR MOWER35Engine Oil Change Drain the used oil while the engine is warm. Warm oil drains quickly and completely.1. Turn the fuel valve to

SERVICING YOUR MOWER36Air Cleaner Service A dirty air filter restricts air flow to the carburetor, reducing engine performance. If you operate the mow

SERVICING YOUR MOWER37Spark Plug ServiceRecommended spark plugs: BPR6ES (NGK) or W20EPR-U (DENSO)For good performance, the spark plug must be properly

INTRODUCTION2A FEW WORDS ABOUT SAFETY Your safety and the safety of others is very important, and using this lawn mower safely is an important respo

SERVICING YOUR MOWER38SPARK ARRESTER SERVICE (optional equipment) Your lawn mower engine is not factory-equipped with a spark arrester. In some area

SERVICING YOUR MOWER39CASTER WHEEL LOCK PINS (HRZ)Remove both front wheel covers. Move the lock lever between the LOCK and RELEASE positions and make

SERVICING YOUR MOWER40FUEL SYSTEMRefuelingFuel tank capacity: 0.29 US gal (1.1 l)If the fuel level is low, refuel in a well-ventilated area with the e

SERVICING YOUR MOWER41Fuel RecommendationsUse unleaded gasoline with a pump octane rating of 86 or higher.These engines are certified to operate on un

42STORAGESTORAGE PREPARATION Proper storage preparation is essential for keeping your lawn mower trouble-free and looking good. The following steps w

STORAGE43FuelGasoline will oxidize and deteriorate in storage. Old gasoline will cause hard starting, and it leaves gum deposits that clog the fuel sy

STORAGE44Draining the Fuel Tank and Carburetor1. Remove the carburetor drain bolt with a 10 mm wrench, and drain the carburetor bowl fuel into an appr

STORAGE45STORAGE PRECAUTIONSIf your mower will be stored with gasoline in the fuel tank and carburetor, it is important to reduce the hazard of gasoli

46TRANSPORTINGBEFORE LOADINGIf the engine has been running, allow it to cool for at least 15 minutes before loading the mower on the transport vehicle

47TAKING CARE OF UNEXPECTED PROBLEMSENGINE PROBLEMSEngine Will Not Start Possible Cause CorrectionCheck control positions. Fuel valve OFF. Turn fuel v

CONTENTS3LAWN MOWER SAFETY... 4IMPORTANT SAFETY INFORMATION..

TAKING CARE OF UNEXPECTED PROBLEMS48VIBRATION PROBLEMSMOWING AND BAGGING PROBLEMSExcessive Vibration Possible Cause CorrectionCheck mower deck and bla

49SET-UPUnpackingRemove all the cardboard from the mower, including the piece around the handlebar.Handlebar SetupLoosen the two knobs on the lower ha

SET-UP50Engine OilThe lawn mower is shipped WITHOUT OIL in the engine. A bottle of oil is included in the box with your mower. Add the entire content

51TECHNICAL & CONSUMERINFORMATIONTECHNICAL INFORMATIONSerial Number Locations There are two serial numbers, one for the mower frame and one for

TECHNICAL AND CONSUMER INFORMATION52Carburetor Modification for High Altitude OperationAt high altitude, the standard carburetor air-fuel mixture will

TECHNICAL AND CONSUMER INFORMATION53Oxygenated FuelsSome conventional gasolines are being blended with alcohol or an ether compound. These gasolines a

TECHNICAL AND CONSUMER INFORMATION54EMISSION CONTROL SYSTEMSource of EmissionsThe combustion process produces carbon monoxide, oxides of nitrogen, and

TECHNICAL AND CONSUMER INFORMATION55Replacement PartsThe emission control systems on your new Honda engine were designed, built, and certified to conf

TECHNICAL AND CONSUMER INFORMATION56Air IndexAn Air Index Information hang tag/label is applied to engines certified to an emission durability time pe

TECHNICAL AND CONSUMER INFORMATION57FRAMEModel HRS216K2 HRR216K2 HRZ216Type PDA SDA PDA SDA TDA TDALength61 1/8 in(1554 mm)63 7/8 in(1621 mm)61 5/8 in

4LAWN MOWER SAFETYIMPORTANT SAFETY INFORMATIONMost accidents with walk-behind mowers can be prevented if you follow all instructions in this manual an

TECHNICAL AND CONSUMER INFORMATION58MAINTENANCEFuel Unleaded gasoline with a pump octane rating of 86 or higherSee page 41.Engine oil SAE 10W-30 See p

TECHNICAL AND CONSUMER INFORMATION59CONSUMER INFORMATIONHonda PublicationsThese publications will give you additional information for maintaining and

TECHNICAL AND CONSUMER INFORMATION60Accessories and Replacement PartsContact a servicing Honda lawn mower dealer to purchase any of these accessories

TECHNICAL AND CONSUMER INFORMATION61Distributor's Limited WarrantyTo Qualify for this Warranty:The product must be purchased in the United States

TECHNICAL AND CONSUMER INFORMATION62Accessories, Replacement Parts, and Apparel WarrantyTo Qualify for this Warranty:1. The accessories, replacement p

TECHNICAL AND CONSUMER INFORMATION63Emission Control System Warranty Your new Honda Power Equipment engine complies with both the U.S. EPA and State

TECHNICAL AND CONSUMER INFORMATION64Only Honda approved replacement parts may be used in the performance of any warranty repairs and must be provided

TECHNICAL AND CONSUMER INFORMATION65Customer Service InformationHonda Power Equipment dealership personnel are trained professionals. They should be a

66INDEXAair cleaner inspection... 36service... 36air index... 56altitude, mod

INDEX67Ggrass bagbagging...27cleaning ...33installation...33removal...

LAWN MOVER SAFETY5IMPORTANT MESSAGE TO PARENTS YOUR CHILDREN’S SAFETY IS VERY IMPORTANT to Honda. That’s why we urge you to read this message before l

INDEX68mowing... 22serial number locations ... 51set-up ... 49shift lever (TDA)description...

QUICK REFERENCE INFORMATION FuelTypeUnleaded gasoline with a pump octane rating of 86 or higher (page 40)Capacity 0.29 US gal (1.1l)Engine oilType S

31VG464200X31-VG4-642040000.2003.07PRINTED IN U.S.A.POM52774-G© 1997–2003 American Honda Motor Co., Inc.—All Rights ReservedRotary MowerHRS216PDA • H

LAWN MOVER SAFETY6SAFETY LABEL LOCATIONS The labels shown here contain important safety information. Please read them carefully. These labels are con

7CONTROLS & FEATURESCOMPONENT & CONTROL LOCATIONSUse the illustrations on the following pages to locate and identify the most frequently used